PRE-DELIVERY INSPECTION

INSPECT and ADJUST, if necessary, the following items to specification:

- Glass, exterior bright metal and paint for damage - Convertible top and detachable hard top (if equipped) for damage - Wheel lug nuts 88—118 N·m (9—12 m-kg, 65—87 ft-lb) - Tire pressure (Refer to Section Q) - All weatherstrips for damage or detachment - Operation of hood release and lock - Operation of fuel lid - Door operation and alignment - Headlight aiming

INSTALL the following parts: - Wheel caps or rings (if equipped) - Outside rearview mirror(s) - Mast antenna

INSPECT and ADJUST, if necessary, the following items to specification:

- Fuel, coolant and hydraulic lines, fittings, connections and components for leaks - Engine oil level - Power steering fluid level (if equipped) - Brake and clutch master cylinder fluid level - Windshield washer reservoir fluid level - Radiator coolant level and specific gravity

- Tightness of water hose clamps (including heater hoses) - Tightness of battery terminals - Drive belt tensions (Refer to Section B) - Accelerator cable and linkage for free movement - CLEAN spark plugs

INSTALL the following parts: - Fuse for accessories

CHECK operation of the following items: - Seat controls (sliding and reclining) - Door locks - Seat belts and warning system - Air bag system using indicator light (if equipped) (Refer to Section T) - Ignition switch and steering lock - Starter interlock switch (clutch pedal) - All lights, including warning and indicator lights - Audible warning system - Horn, wipers and washer - Audio system (if equipped) - Cigarette lighter - Power windows (if equipped) - Heater, defroster and air conditioner at all mode selections (if equipped)

CHECK the following items: - Presence of spare fuses - Upholstery and interior finish

CHECK and ADJUST, if necessary, the following items: - Operation and fit of windows - Pedal height and free play of brake and clutch pedals

- Parking brake 5—7 notches/98 N (10 kg, 22lb)

CHECK the following items: - Initial ignition timing 10° ± 1° BTDC (with diagnosis connector TEN and GND terminals connected) (Refer to page F-75) - Idle speed 850 ± 50 rpm (with diagnosis connector TEN and GND terminals connected) (Refer to page F-76)

CHECK the following items: - Underside fuel, coolant and hydraulic lines, fittings, connections and components for leaks - Tires for cuts or bruises - Steering linkage, suspension, exhaust system and all underside hardware for looseness or damage - Manual transmission oil level - Rear axle oil level

CHECK the following items: - Brake operation - Clutch operation - Steering control - Operation of meters and gauges - Squeaks, rattles and unusual noise - Overall engine performance - Seat belt emergency locking retractors - Cruise control system (if equipped)

REMOVE seat and floor mat protective covers CHECK for necessary owner information materials, tools and spare tire in vehicle